Ausmini
It is currently Tue Aug 05, 2025 4:13 pm

All times are UTC + 10 hours




Post new topic Reply to topic  [ 44 posts ]  Go to page 1, 2, 3  Next
Author Message
 Post subject: pulling engine out
PostPosted: Sun Aug 31, 2008 5:10 pm 
Offline
998cc
998cc
User avatar

Joined: Fri Feb 29, 2008 4:33 pm
Posts: 1039
Location: wollongong
hey fellas, i have something to confess... i have just been unfaithful and was on another mini forum :( ... anyways im going to pull my 998 out soon. and need to know what to do :D and need to know what some things are and LOOK like :D

heres a list i found on another forum

Checklist:

trolley Jack, pair axle stands. Have a load of plastic bags handy, and bag up &
label each things that comes off - if you dont recognise the part, label it!
Makes refitting sooo much easier.

- disconnect/remove battery
- remove bonnet - held on with 4x nuts, 7/16" heads
- remove the split pins from the eng of the CV's on the front, and
loosen the hub nuts- do this now, as it's near impossible with the car in
the air! You may need the help of an assistant to hold the brake
pedal down while doing this.
- Loosen the wheel nuts
- Jack the car up, and support on axle stands
- remove the roadwheels
- drain the engine oil
- drain the coolant and remove the radiator
- disconnect the fuel line and choke & accelerator cables from the carb
- remove the exhaust, inlet/exhaust manifold, and carb.
- If you have an inline brake servo fitted, undo the 3 retaining bolts
and push to one side in the engine bay
- disconnect the wiring to the starter motor and then remove motor
- disconnect & remove alternator
- disconnect the wiring for the oil pressure light and temp light
- disconnect the top engine steady bar
- disconnect the bottom engine steady bar
- disconnect any engine to body earth straps
- if you have disc brakes, remove the calipers, but leave the hoses
connected.
- working under the car, remove the lock bolt and roll pin holding the
gear linkage into the gearbox.

- working inside the car, undo the screws and nuts holding the gear
linkage in place, and remove by dropping under the car.
- split all 3 balljoints on each hub, and drop the top joint out from the top
arm - leave the botom one in for now.
- working under the car, and preferably with the correct tool, split the
pot joints from the gearbox. When free, remove the hubs from the bottom
arms and ease away from the box, leaving the drive shaft complete
.
- working from each side under the arch, remove the 2 nuts/bolds on the
engine mounts
- that's it - the engine is now free - so get a sling/rope/chain round it and get it out!

In true Haynes fashion....refitting is reverse of removal....


so thats the list. what are the items underlined? what do they do? and what do they look like?

cheers leighton

_________________
1975 Leyland Mini: 1060cc - resto/ ex-hsc project.


Top
 Profile  
 
 Post subject:
PostPosted: Sun Aug 31, 2008 5:43 pm 
Offline
1275cc
1275cc

Joined: Wed Jan 05, 2005 4:50 pm
Posts: 2690
Location: Wollongong
I would do a few things differently. First of all, disconnect and remove carbs alternator, coil etc before putting it up on stands. I do this because i prefer to work on the car when it is safe and sound on the ground as much as possible.

Secondly i wouldn't remove the radiator, just pull it out with the motor.

the only other thing is, if you don;t have ball joints than the process is different. But from memory you do so, i guess you are on track.

In terms of lifting the motor out, it requires a little bit of manouvoring, so it helps to have two people. Also i don;t use a sling, rather just some chain bolted to the head studs, or make up a bracket, (there is a design on here somewhere).

Ryan

_________________
Ryan Filippi
Minis In The Gong
[email protected]
www.minisinthegong.com.au


Top
 Profile  
 
 Post subject:
PostPosted: Sun Aug 31, 2008 5:50 pm 
Offline
998cc
998cc
User avatar

Joined: Fri Feb 29, 2008 4:33 pm
Posts: 1039
Location: wollongong
yeah that would be alot safer...

so the head studs will with stand the weight of the engine??


leighton

_________________
1975 Leyland Mini: 1060cc - resto/ ex-hsc project.


Top
 Profile  
 
 Post subject:
PostPosted: Sun Aug 31, 2008 6:03 pm 
Offline
1275cc
1275cc

Joined: Wed Jan 05, 2005 4:50 pm
Posts: 2690
Location: Wollongong
I'm trying to find photos of the bracket for you
here is a pic of it on doogies engine, but hard to see
Image

Ryan

_________________
Ryan Filippi
Minis In The Gong
[email protected]
www.minisinthegong.com.au


Top
 Profile  
 
 Post subject:
PostPosted: Sun Aug 31, 2008 6:09 pm 
Offline
998cc
998cc
User avatar

Joined: Fri Feb 29, 2008 4:33 pm
Posts: 1039
Location: wollongong
yeah it is hard to see. where does it attach to.

cheers

_________________
1975 Leyland Mini: 1060cc - resto/ ex-hsc project.


Top
 Profile  
 
 Post subject:
PostPosted: Sun Aug 31, 2008 6:11 pm 
Offline
1360cc
1360cc
User avatar

Joined: Sat May 08, 2004 9:01 pm
Posts: 6844
Location: Cairns, Nrth QLD
Middle front head stud

_________________
Image
http://www.youtube.com/user/Hanras


Top
 Profile  
 
 Post subject:
PostPosted: Sun Aug 31, 2008 6:19 pm 
Offline
1275cc
1275cc

Joined: Mon Mar 22, 2004 7:41 pm
Posts: 4319
Location: Plumpton, NSW
Search the how to's for "Engine lifting bracket" - there is one made simply from angle iron and a d shackle which supports the weight across two head studs. Many have used this design and it works.

_________________
Image


Top
 Profile  
 
 Post subject:
PostPosted: Sun Aug 31, 2008 6:28 pm 
Offline
High heel ninja
User avatar

Joined: Sat Apr 10, 2004 6:36 pm
Posts: 4979
Location: Radelaide, South Australia
ryan wrote:
I would do a few things differently. First of all, disconnect and remove carbs alternator, coil etc before putting it up on stands. I do this because i prefer to work on the car when it is safe and sound on the ground as much as possible.

Secondly i wouldn't remove the radiator, just pull it out with the motor.

the only other thing is, if you don;t have ball joints than the process is different. But from memory you do so, i guess you are on track.

In terms of lifting the motor out, it requires a little bit of manouvoring, so it helps to have two people. Also i don;t use a sling, rather just some chain bolted to the head studs, or make up a bracket, (there is a design on here somewhere).

Ryan


In my opinion removing all that stuff is not needed, take the neck of the carby, that will clear the scuttle panel, alternator does'nt foul anything on the way out, as i said just my opinion.

Doogie

_________________
I won Hay once, here's the pic to prove it..
Image

Hay, it's not about the car, it's not about the venue, it's about the people that come here. Peter Dwyer, Mayor of Hay NSW.


Top
 Profile  
 
 Post subject:
PostPosted: Sun Aug 31, 2008 6:28 pm 
Offline
SooperDooperMiniCooper ExpertEngineering
User avatar

Joined: Fri Apr 29, 2005 9:46 am
Posts: 18888
Location: Under the bonnet son!
A nice balance point is when the contact point of the hook is over the dipstick hole (so a little out from in between the studs). The engine balances just perfectly and allows the engine to come out with the radiator still attached, the oil filter on and still clear the differential housing at the back of the engine bay.

_________________
SooperDooperMiniCooperExpertEngineering

All garage work involves equal measures of enthusiasm, ingenuity and a fair degree of irresponsibility.


Top
 Profile  
 
 Post subject:
PostPosted: Sun Aug 31, 2008 6:41 pm 
Offline
998cc
998cc

Joined: Sun Nov 06, 2005 5:41 pm
Posts: 860
Location: Adelaide
You can remove (or replace) the engine with all the bits attached including the carbs, alternator and radiator, or removed. If the bits are attached the job is a lot quicker. If you remove all the bits there is less chance of scratching the paint. Thus, on a new pearl pink paint job I removed all the bits and took the time. Proper engine lifting bracket makes it easy as the engine is dropped in at the correnct angle, critical if you have a remote change gear box. (This engine is a rod change, and can thus be dropped straight down, more or less)
The paper on the front stops the chains from marking the paint, or chrome work if it is in place.
The orange rope in the first photo is holding up the extractors, as this has a fully welded LCB exhaust system.

Image

Image


Top
 Profile  
 
 Post subject:
PostPosted: Sun Aug 31, 2008 6:47 pm 
Offline
1275cc
1275cc
User avatar

Joined: Thu Dec 21, 2006 11:50 am
Posts: 2639
Location: Bentleigh Melbourne Victoria Australia
Is there a mini forum other than ausmini? If so, I don't want to know about it. It is hard enough reading all the stuff on here!

_________________
Flute - 68 MK I Cooper S
Member: VMCI #2474
Member: International Mini Model Collectors Club


Top
 Profile  
 
 Post subject:
PostPosted: Sun Aug 31, 2008 6:48 pm 
Offline
1275cc
1275cc

Joined: Wed Jan 05, 2005 4:50 pm
Posts: 2690
Location: Wollongong
Yeah, doogie i would normally agree with you, however in leigtons case he will be pulling the motor down for a rebuild anyway, so he is going to have to take it off anyway. Also depending on the type of alternator, it wont always clear (in a round nose).
Ryan

_________________
Ryan Filippi
Minis In The Gong
[email protected]
www.minisinthegong.com.au


Top
 Profile  
 
 Post subject:
PostPosted: Sun Aug 31, 2008 6:55 pm 
Offline
1098cc
1098cc
User avatar

Joined: Tue Jan 11, 2005 9:07 pm
Posts: 1336
Location: Emu Plains, NSW
1310/71 wrote:
Search the how to's for "Engine lifting bracket" - there is one made simply from angle iron and a d shackle which supports the weight across two head studs. Many have used this design and it works.

Here it is http://www.ausmini.com/forums/viewtopic ... ng+bracket
I have made one of these and used it about a dozen times.
Great piece of gear as the motor sits at a good angle.
Cheers Pete

_________________
A recent study found the average Aussie walks about 900 miles a year
Another study found Aussies drink, on average, 22 gallons of alcohol a year
That means, on average, Australians get about 41 miles per gallon

Kind of makes you proud to be an AUSSIE


Top
 Profile  
 
 Post subject:
PostPosted: Sun Aug 31, 2008 6:55 pm 
Offline
998cc
998cc
User avatar

Joined: Fri Feb 29, 2008 4:33 pm
Posts: 1039
Location: wollongong
ok thanks for all that..... whats the difference between a remote nad rod change gearbox??? ive got a '75 clubby. cheers leighton

_________________
1975 Leyland Mini: 1060cc - resto/ ex-hsc project.


Top
 Profile  
 
 Post subject:
PostPosted: Sun Aug 31, 2008 6:57 pm 
Offline
998cc
998cc
User avatar

Joined: Fri Feb 29, 2008 4:33 pm
Posts: 1039
Location: wollongong
Quote:
Here it is http://www.ausmini.com/forums/viewtopic ... ng+bracket
I have made one of these and used it about a dozen times.
Great piece of gear as the motor sits at a good angle.
Cheers Pete


yeah i had a look at that... looks like a nice simple design.

_________________
1975 Leyland Mini: 1060cc - resto/ ex-hsc project.


Top
 Profile  
 
Display posts from previous:  Sort by  
Post new topic Reply to topic  [ 44 posts ]  Go to page 1, 2, 3  Next

All times are UTC + 10 hours


Who is online

Users browsing this forum: No registered users and 96 guests


You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum

Jump to:  

© 2016 Ausmini. All garage work involves equal measures of enthusiasm, ingenuity and a fair degree of irresponsibility.